Frigidaire FGHI2164QP FGHT2046QP FGHI2164QE wiring

Wednesday, March 29, 2017
Download

PERFORMANCE DATA SERVICE DATA SHEET IMPORTANT NO LOAD & NO DOOR OPENINGS AT MID-POINT CONTROL SETTING PLEASE RETURN THIS SHEET TO ITS ORIGINAL LOCATION. A01511901 Type A With Run/Start Capacitor 65°F (18°C) Ambient 90°F (32°C) Ambient STANDARD - AUTOMATIC DEFROST SERVICE MODE Operating Time 25 to 35% 45 to 55% TOP MOUNT FREEZER - R134a SERVICE MODE will step through available tests to diagnose individual electrical circuits. Fresh Freezer Temperature 2° to 8°F (-17° to -13°C) 0° to 5°F (-18° to -15°C) Food compartment light will be OFF while in SERVICE MODE. Refrigerator Temperature 35° to 40°F (2° to 4°C) 35° to 40°F (1° to 4°C) --> Press the door switch 3 times and hold the 4th press until 1 long enter/exit Low Side Pressure (cut-in) 8 to 16 psig ( 55 to 110 kPa) 8 to 16 psig (55 to 110 kPa) IMPORTANT SAFETY NOTE beep is heard. The door switch must be pressed 4 times in 2 seconds. Low Side Pressure (cut-out) 1 to 4 psig (7 to 28 kPa) 1 to 4 psig (7 to 28 kPa) The information provided herein is designed to assist qualified repair personnel only. initiate first/next test --> Press the door switch 2 times; 2 short beeps acknowledge selection. High Side Pressure 110 to 120 psig 150 to 175 psig Untrained persons should not attempt to make repairs due to the possibility of electrical 1 Compressor Press the FF door switch twice to start the first test. In each test, the (last 1/3 cycle) (758 to 827 kPa) (1034 to 1207 kPa) shock. Disconnect power cord before servicing this appliance. component listed will be powered on. The component will stay powered 2 Heater until the next test is activated, or until 5 minutes of inactivity expire. Listen Wattage (last 1/3 cycle) 140 to 185 140 to 185 IMPORTANT for operating sounds; feel for heat or air flow, as appropriate, to determine 3 FF Light Amps (running) 1.1 to 1.6 1.1 to 1.6 If any green grounding wires are removed during servicing, they must be returned to their the result of each test. Press the FF door switch twice again to advance original position and properly secured. 4 Evaporator Fan between tests. Two beeps will sound to confirm the next test has started. Base Voltage 115 vac (127 vac max) 115 vac (127 vac max) Refrigerant Charge 4.25 oz. (121 g) DEFROST SPECIFICATIONS CAUTION Defrost All electrical parts and wiring must be shielded from torch flame. DO NOT allow Safety Thermostat Heater Thermis- tor torch to touch insulation; it will char at 200°F and flash ignite (burn) at 500°F. Normal Cooling Service Mode Excessive heat will distort the plastic liner. Mode Cabinet Size: 18’/20’ Cut-in Cut-out Watts Ohms Termina- Press Door Switch 3 Press Door Switch tion Times and Hold 4th Press Until 2 Times Long Beep Test 1: 2 Beeps Test 2: Power ON 110°F 135°F 47°F DOOR AJAR ALARM 375 35 Press Door Switch Compressor ON to Defrost Heater (43.3°C) (57.2°C) (8.3°C) Condition: Fresh Food Door is left open for more than 5 minutes and alarm sounds. Enters Service 2 Times To Exit Service Mode from Press Door Switch CONDENSER FAN MOTOR 2 Beeps Press Door Switch any Test Press Door Switch 2 Times Duration: Alarm will sound for 2 minutes, then stop. If the “Door Ajar” condition remains, Mode 2 Times 3 Times and Hold 4th Press 2 Beeps Watts RPM Amps the alarm will repeat every 30 minutes for two intervals. Manual Defrost 2 Beeps 3.1 1100 CW Opposite Shaft 0.03 Running Fresh Food Light: After 15 minutes of “Door Ajar” condition, the Fresh Food light will turn off. Test 4: Evaporator Test 3: Fresh Press Door Switch 5 Times to EVAPORATOR FAN MOTOR Reset: Close the Fresh Food door or Press the Fresh Food Door switch. Fan ON Press Door Switch Food Light ON Enter Manual Defrost. POR Watts RPM Amps MANUAL DEFROST or Enter Service Mode to Exit 2 Times Manual Defrost. 2 Beeps P/N A01437001 6.2 2600 CW 0.05 Running Unit will complete normal defrost cycle. ICE MAKER SPECIFICATIONS enter --> Press the FF door switch 5 times in 2 secs.; Alarm sounds 5 short beeps Electrical 115 vac (127 vac max) 60 Hertz to acknowledge MANUAL DEFROST. Thermostat Opens at 48°F (9°C) Closes at 15°F ( -9°C) (ice maker exit --> Cycle power to the unit or enter and exit with black housing) SERVICE MODE. (See SERVICE MODE) 108 mm Heater Wattage 165 vac 9°F (-13°C) (ice maker Defrost is terminated when defrost thermistor located on the evaporator coil reaches 47°F. TEMPERATURE/RESISTANCE CHART with white housing) FOR FRESH FOOD THERMISTOR AND DEFROST THERMISTOR Safety Thermostat in the defrost circuit is a safety device only. It will interrupt power to the defrost ICE MAKER CONNECTOR PLUG CONNECTIONS heater at 135°F. °F kOHMS °F kOHMS °F kOHMS °F kOHMS Wire Number Wire Color Connects to: -10 83.88 11 47.25 32 27.20 53 16.87 1 Green / Yellow Ground -9 81.56 12 46.02 33 27.04 54 16.49 2 Yellow Water Valve -8 79.32 13 44.84 34 26.38 55 16.13 -7 77.15 14 43.67 35 25.75 56 16.77 3 Black Line -6 75.04 15 42.55 36 25.13 57 15.41 4 Light Blue Neutral -5 73.02 16 41.45 37 24.53 58 15.07 -4 71.02 17 40.39 38 23.95 59 14.74 ICE MAKER INFORMATION -3 69.08 18 39.36 39 23.38 60 14.42 -2 67.16 19 38.36 40 22.83 61 14.10 Test Cycling: Remove cover by inserting screwdriver in notch at -1 65.34 20 37.39 41 22.29 62 13.79 bottom and prying cover from housing. Use screwdriver to rotate motor gear counter- 0 63.55 21 36.44 42 21.77 63 13.49 clockwise until holding switch circuit is completed. All components of ice maker should 1 61.82 22 35.53 43 21.26 64 13.21 function to complete the cycle. 2 60.15 23 34.63 44 20.77 65 12.92 3 58.20 24 33.78 45 20.29 66 12.65 Water Fill Volume: The water fill adjustment screw will change the fill time. One 4 56.97 25 32.94 46 19.83 67 12.38 full turn is equal to 20cc (.68 oz.). The correct fill is 102 to 130cc (3.4 to 4.3 oz.). 5 55.43 26 32.13 47 19.37 68 12.11 When a water valve is replaced, the fill volume must be checked. 6 53.97 27 31.33 48 18.92 69 11.85 7 52.53 28 30.57 49 18.49 70 11.60 8 51.16 29 29.83 50 18.07 71 11.36 9 49.81 30 29.10 51 17.66 72 11.12 10 48.51 31 28.39 52 17.26 73 10.88

NOTE: - - - - - - - DENOTES NOT ON ALL MODELS. LADDER SCHEMATIC-TOP MOUNTS WITH OPTIONAL ICE MAKER, FREEZER LIGHT OR MID-LEVEL LIGHTING (NEUTRAL LT. BLUE) (LINE-BLACK) FREEZER COMPARTMENT MACHINE COMPARTMENT GRN/YEL COMPRESSOR MAIN BOARD HOUSING ASSEMBLY RED LT. BLUE ERF-1500 CONDENSER FAN RED LOW VOLTAGE HIGH VOLTAGE LT.BLUE ERF-1500 RED RED RED LT.BLUE LT.BLUE BOARD CN2-8 +5V NEUTRAL CN5-3 EVAPORATOR FAN COMP CN1-5 GREY/BLK GREY/BLK GREY/BLK RED RED CN2-9 SENSOR (FF NTC) COMP CN1-5 FAN CN1-9 SAFETY/ EVAPORATOR FAN COIL HEATER DEFROST BI-METAL BLACK HEATER CN1-3 YEL/GREY YEL/GREY YEL/GREY BLACK CN2-12 DOOR LINE CN5-1 FRESH FOOD LIGHT SWITCH GREY FRESH FOOD LIGHT GREY GREY BROWN BROWN LAMP CN1-7 CN2-1 GND HEATER CN1-3 NEUTRAL COIL COVER ORANGE ORANGE ORANGE YEL/BLK YEL/BLK CN1-1/CN5-3 NEUTRAL ICE MAKER CN2-11 CTL LAMP CN1-7 LINE CN5-1 GREY/WHITE GREY/WHITE GREY/WHITE RED/WHITE RED/WHITE CN2-10 DEFROST (FZ FAN CN1-9 LINE BLACK BLACK NTC) RED/WHITE GRN/YEL LT. BLUE YELLOW YELLOW GRN/YEL GRN/YEL AUTO GRN/YEL PORKCHOP ICE MAKER RED/WHITE RED/WHITE RED/WHITE RED/WHITE I/M WATER VALVE LT. BLUE YEL/BLK YEL/BLK DEFROST BI-METAL LT. BLUE LT. BLUE LT. BLUE BROWN BROWN BROWN BROWN COIL HEATER RED YELLOW YELLOW GREY/WHITE RED GREY/WHITE GREY/WHITE BLACK BLACK DEFROST THERMISTOR SPLICE PORKCHOP COMPRESSOR WIRING LT.BLUE LT.BLUE P.T.C. STARTER WITH RUN CAPACITOR SPLICE GRY/YEL GREY/YEL LT.BLUE LT.BLUE LT.BLUE LT.BLUE BLACK GRY/YEL RED LT.BLUE YEL RED GRN/YEL LT.BLUE RED SEE COMPRESSOR START SERVICE CORD WIRING 6 3 RUN CAPACITOR CONDENSER FAN S S I/M WATER VALVE RUN 2 5 ORANGE 1 YEL/GREY L GRY/BLK M YEL/BLK LT. BLUE GREY M RED C RED COMR PTC OVERLOAD MOTOR STARTER FRESHFOOD COMPARTMENT LIGHT, AIR & WATER BOX ORANGE YEL/GREY GRY/BLK GREY RED RED LT. BLUE FRESHFOOD YEL/BLK LIGHT RED FRESHFOOD THERMOSTAT SLIDE POTENTIOMETER ORANGE GREY * CAPACITOR IS ONLY USED WITH SOME P.T.C. MODELS. FRESHFOOD GREY DOOR SWITCH YEL/GREY Wire Diagram A01475501